天然氣發電機組是以天然氣、LPG、LNG、油田伴生氣等高熱值氣體為燃料的點火式氣體機。在非增壓機型的基礎上增加了增壓系統和中冷系統，冷卻系統采用高低溫循環分開的方式，高溫循環冷卻氣缸、機體、氣缸蓋等高溫部件，低溫循環冷卻增壓后的燃氣、空氣以及油冷器。

　　Natural gas power generation units are based on natural gas LPG、LNG、 A ignition gas engine that uses high calorific value gases such as associated gas from oil fields as fuel. On the basis of non supercharged models, a supercharging system and an intercooler system have been added. The cooling system adopts a high and low temperature cycle separation method, with high temperature cycle cooling the cylinder, body, cylinder head and other high-temperature components, and low temperature cycle cooling the supercharged gas, air and oil cooler.

　　一、天然氣介紹

　　1、 Introduction to Natural Gas

　　天然氣——主要成分是甲烷，含量達90%，燃燒產生的氮氧化物、碳氫化物和一氧化碳遠遠低于國家規定的排放標準，無粉塵污染；天然氣的熱轉化效率為65%，與石油液化氣相當，高于煤炭；按等熱值換算，天然氣的價格已經低于煤炭，也遠遠低于石油。天然氣可用作民用、發電、化工原料和工業燃料等，對煤炭、石油進行有效替代。如可替代居民用煤制氣，替代煤炭和石油作為氮肥原料，替代石腦油作為乙烯原料，替代石油作為汽車發動機燃料等。

　　Natural gas - the main component is methane, with a content of up to 90%. The nitrogen oxides, hydrocarbons, and carbon monoxide produced by combustion are far below the national emission standards, and there is no dust pollution; The thermal conversion efficiency of natural gas is 65%, which is comparable to liquefied petroleum gas and higher than coal; According to the equivalent calorific value conversion, the price of natural gas is already lower than that of coal and far lower than that of oil. Natural gas can be used as a civilian, power generation, chemical raw material, and industrial fuel, effectively replacing coal and oil. If it can replace residential coal to gas, replace coal and petroleum as nitrogen fertilizer raw materials, replace naphtha as ethylene raw material, replace petroleum as automotive engine fuel, etc.

　　LPG是液化石油氣，LPG主要成分是丙烷。

　　LPG is liquefied petroleum gas, and its main component is propane.

　　CNG是壓縮天然氣，天然氣經過壓縮到20MPa形成的高壓天然氣稱為壓縮天然氣（CNG）。

　　CNG is compressed natural gas, and the high-pressure natural gas formed by compressing natural gas to 20MPa is called compressed natural gas (CNG).

　　LNG是液化天然氣，天然氣經過超低溫深冷到-162℃形成的液態天然氣稱為液化天然氣（LNG）。機組對天然氣的要求（在距離燃氣機組燃氣進氣閥1m內）：①　天然氣中CH4體積含量≥70%；

　　LNG is liquefied natural gas, and the liquid natural gas formed by ultra-low temperature deep cooling of natural gas to -162 ℃ is called liquefied natural gas (LNG). Requirements for natural gas by the unit (within 1 meter of the gas inlet valve of the gas unit): ① The CH4 volume content in natural gas is ≥ 70%;

　?、凇√烊粴鈮毫?0～200kpa，壓力變化率≤1kpa/min；

　?、?Natural gas pressure is 80-200kpa, with a pressure change rate of ≤ 1kpa/min;

　?、邸2S≤20mg/Nm3；

　?、?H2S ≤ 20mg/Nm3;

　?、堋√烊粴庵兴趾俊?0g/Nm3；

　　④ The moisture content in natural gas is ≤ 40g/Nm3;

　?、荨‰s質粒度≤5μm，雜質含量≤30mg/Nm3。如果可燃氣體中含硫及氨成分較高，不僅會嚴重腐蝕火花塞電極，而且會使機油中的酸值增加，腐蝕機組內部零件。同時易于生成沉淀物，增加對發動機的磨損和腐蝕。

　?、?Impurity particle size ≤ 5 μ m, impurity content ≤ 30mg/Nm3. If the combustible gas contains high levels of sulfur and ammonia, it will not only severely corrode the spark plug electrode, but also increase the acid value in the engine oil and corrode the internal components of the unit. At the same time, it is easy to generate sediment, which increases the wear and corrosion of the engine.

　　適用場合：①　油田石油伴生氣發電；②　工業園區；③　石油加工化工廠；④　用天然氣發電作為備用電源；⑤　油井配套單機提供動力；

　　Applicable occasions: ① Oil field associated gas power generation; ② Industrial park; ③ Petroleum processing and chemical plants; ④ Using natural gas to generate electricity as a backup power source; ⑤ Oil well supporting single machine provides power;

　　本文由  天然氣發電機組 友情奉獻.更多有關的知識請點擊  http://www.blmhz.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from a natural gas generator set For more related knowledge, please click http://www.blmhz.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.